FIRE RETARDANT SPRAY
FIRE RETARDANT COATING AND TREATMENT
| LABEL |
 |
CALL US FOR OUR DAILY DISCOUNT ! ! ! Direct 1-817-740-9197 |
TEST |
Material tested 100% Cotton 100% Synthetic |
RESULTS |
|
CFR 1632.4 (FF 4-72) FAR 25.853 a & b CALIF 1237.1 NFPA 701 CAL TECH 117-F NY-NJ PORT BOSTON |
Mattress Ticking Mattress Pads Upholstery Textiles Aircraft Interiors Draperies Wall Coverings Cotton Muslin Fabrics Films |
Class B Passed ClassA Passed Passed Passed Passed |
| ICC - Intertek CERTIFICATE OF COMPLIANCE |
| NFPA 701 Method 1 | NFPA 701 Method 1ASTM D2859 synthetic carpet |
| NFPA 701 Method 2 | ASTM D2859 Cotton-Jute carpet |
| ASTM E1353 Upholstered furniture (upholstery textiles) | |
| LOW VOC |
FABRIC SAFE 2 exterior flame retardant spray penetrant for canvas and leather
FABRIC SAFE 2 TECHNICAL DATA
(Exterior / Interior)
PRODUCT DESCRIPTION: Aqueous Based Resin
Product |
Analysis |
||
|---|---|---|---|
| Total Solids | 26.7 - 31.5% |
PH |
4.6 - 5.2 |
| Weight per gallon | 9.4 lbs |
Flash point |
Non-Flammable |
| Specific gravity | 1.10 |
Color | Water clear at 78°F. - Slight haze at 50°F. or lower |
| Volatability | Non-Volatile |
Solvents | Water(Contains no petroleum or derivatives of petroleum) |
| Anti-Fungus | Excellent Resistance |
Bacterial | Good Resistance |
| Linear shrinkage | None |
Moisture Absorption | None |
| Corrosive | Mildly |
Toxic | None |
| Insects, rodents, aspergilli And other types of molds |
Excellent resistance |
Not harmful to | plants |
RECOMMENDED USE: Exterior / Interior
FLAME SAFE FABRIC SAFE 2 is a fire retardant that can be applied to materials such as:
| Canvas | Canvas awnings | Canvas Tents |
| Burlap | Leather (treat from the backside) | |
ENVIRONMENTAL REGULATION:
This product complies with U. S. Federal Regulations concerning the use of lead in paint and hydrocarbon emissions.
QUICK REFERENCE FOR APPLYING FABRIC SAFE 2
| MATERIAL | APPLICATION | COVERAGE |
| Canvas, Leather, Canvas tents, Canvas Awnings, Burlap | Treat with retardant according to manufacturer's specifications Apply with a mist applicator held 6" -8" from surface Allow to dry before use Treat both sides where possible |
200 -300 sq. ft. per gallon Do not saturate, retardant will easily penetrate material |
EXTERIOR:
Treatment of canvas tents and awnings with Fabric Safe 2 for canvas, gives excellent protection against ignition, flame spread and afterglow. It forms a barrier which inhibits ignition of the treated material and restricts the char to the immediate area touched exposed to flame. Fabric Safe 2 for canvas is a water-based, clear, odorless and non-toxic fire retardant. All surfaces to be treated must be clean. Due to the vast variety of tent materials, it is important to check for color fastness. This is done by applying a small amount of retardant to an obscure area and letting it dry ( a hair dryer will aid in drying). Apply retardant as it comes from the container. DO NOT DILUTE OR MIX FABRIC SAFE WITH ANY OTHER PRODUCTS. The coverage rate of Fabric Safe 2 is 200 to 300 square feet per gallon depending on the type and weight of the material being treated. All treated textiles/fabrics lose some of their fire retardant qualities after deep cleaning, therefore re-treatment with Fabric Safe 2 is necessary to achieve maximum results. Be sure all materials are dry before applying Fabric Safe 2 for canvas. A water based moisture sealer can be applied after applying Fabric Safe for canvas.
CAUTION:
Product must not freeze. It MUST NOT be thinned or diluted.
OVERSPRAY:
The overspray will not harm plants or animals. Spills can be flushed with water.
A rag wetted with bleach and water mix will clean up spotting.
CLEAN UP PROCEDURE:
1. Run bleach and water mix through spray mist applicator for cleaning any residue.
2. Rinse sponges with bleach and water mix.
SAFETY FIRST:
If eye contact occurs, flood with water for fifteen (15) minutes and call a physician. KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE INTERNALLY.
| CALL FOR OUR DAILY DISCOUNT ! ! |
| Call for pricing and ordering 1-800-333-9197 |